Experimental study on prestressed assembly steel strut system in foundation excavations
-
摘要: 预应力型钢组合支撑是近年来国内出现的新型钢支撑,该项技术除了具有可回收的优点外,还具有高强连接、可施加预应力、可靠性高等优点,因而在国内的应用不断增多。虽然该项技术已渐趋成熟,但是仍有一些问题亟待研究。因而在支撑跨度较大、土质较差的杭州城西某工程进行多组支撑加压、观测试验。型钢组合支撑实际刚度略小于理论刚度,支撑预应力锁定值是影响基坑变形的关键因素,应采取措施保证支撑预应力满足要求;型钢组合支撑的承载力取决于支撑的稳定性,型钢组合支撑的承载力满足设计要求,且有较高的冗余度;型钢组合支撑的温度应力变化幅度约占实际轴力的29.1%,占设计轴力的7.4%,温度应力对支撑承载力的影响处于可控水平。Abstract: The prestressed assemble steel support system (PASS) is an innovative steel support which can be recycled and prestressed and has a lot of advantages, such as high-strength connection and high reliability, so it has been used more and more in China. To solve some problems urgently, a series of PASS pressure and observation experiments are carried out in a project with large span and poor soil in the west of Hangzhou. The experiment shows that the measured stiffness of PASS is slightly less than that in theory, and the critical factor for deformation of the foundation pit is the supporting prestress. The carrying capacity of PASS depends on the stability of support, so it should meet the design requirements and has a lertain redundancy. The maximum stress of PASS varing with temperature is about 29.1% of the actual axial force or 7.4% of the design axial force, and the influences of temperature stress are controllable.
-
Keywords:
- stability /
- steel struts /
- deep excavation
-
[1] 张旷成, 李继民. 杭州地铁湘湖站“08.11.15”基坑坍塌事故分析[J]. 岩土工程学报, 2010, 32(增刊1): 338-342.
(ZHANG Kuang-cheng, LI Ji-min.Accident analysis for ‘08.11.15’ foundation pit collapse of Xianghu Station of Hangzhou metro[J]. Chinese Journal of Geotechnical Engineering, 2010, 32(S1): 338-342. (in Chinese))[2] COI(2005). Report of the Committee of Inquiry into the incident at the MRT circle line worksite that led to collapse of Nicoll Highway on 20 April 2004[R]. Singapore City: Ministry of Manpower. [3] 程雪松, 郑刚, 邓楚涵, 等. 基坑悬臂排桩支护局部失效引发连续破坏机理研究[J]. 岩土工程学报, 2015, 37(7): 1249-1263.
(CHENG Xue-song, ZHENG Gang, DENG Chu-han, et al.Study of the mechanism of progressive collapse induced by partial failure of cantilever contiguous retaining piles[J]. Chinese Journal of Geotechnical Engineering, 2015, 37(7): 1249-1263. (in Chinese))[4] 李瑛, 陈东, 刘兴旺, 等. 预应力型钢组合支撑应用于软土基坑支护[J]. 岩土工程学报, 2014, 36(增刊1): 51-55.
(LI Ying, CHEN Dong, LIU Xingwang, et al.Application of prestressed assemble steel support system in retaining structures for foundation pits in soft soils[J]. Chinese Journal of Geotechnical Engineering, 2014, 36(S1): 51-55. (in Chinese))[5] DB33T1142—2017基坑工程装配式型钢组合支撑应用技术规程[S]. 2017. (DB33T1142—2017 Technical specification for assembly steel strutssystem in foundation excavation[S]. 2017. (in Chinese)) [6] JGJ 120—2012 建筑基坑支护技术规程[S]. 2012.
(JGJ 120—2012 Technical specification for retaining and protection of building foundation excavations[S]. 2012. (in Chinese)) -
期刊类型引用(8)
1. 葛新鹏. 基坑工程完全可回收支护结构设计与应用. 山西建筑. 2024(06): 78-82+86 . 
百度学术
2. 陈伟，陈晓洁. 明挖法深大基坑轴向拉压双向受力装配式支撑结构施工技术. 施工技术(中英文). 2024(15): 26-30 . 百度学术
3. 李列娟，董红刚，马炳剡，刘建明. 软土地区复杂基坑支护综合施工技术. 施工技术(中英文). 2024(16): 92-96 . 百度学术
4. 赵升峰，汪敏营，邬喜春，李明东. 全钢结构基坑支护若干问题分析. 江苏建筑. 2024(05): 105-109 . 百度学术
5. 张双. 基于装配式预应力型钢组合支撑的基坑分层开挖过程模拟分析. 市政技术. 2023(06): 121-128 . 百度学术
6. 王晓双，张菊连，吴申申，张衡. 双八字组合型钢支撑预应力施加方法与校验. 工业技术创新. 2022(02): 141-148 . 百度学术
7. 李潇，蔡璐. H型钢组合支撑在地铁基坑中的应用研究. 岩土工程技术. 2021(02): 84-87 . 百度学术
8. 赵宏宇，高春雷，许利东，童根树，张磊. 采用预应力型钢组合支撑的某软土深基坑监测分析研究. 工程勘察. 2020(11): 7-12 . 百度学术
其他类型引用(5)
计量
- 文章访问数: 258
- HTML全文浏览量: 5
- PDF下载量: 158
- 被引次数: 13
下载:
