Sludge solidification based on carbon dioxide foam cement slurry

FENG Tugen; LI Zhiping; ZHANG Jian; XIE Kang

doi:10.11779/CJGE20230869

Volume 46 Issue 12

Turn off MathJax

Article Contents

Abstract

References

Supplements

Chinese Journal of Geotechnical Engineering > 2024 > 46(12): 2538-2547. > DOI: 10.11779/CJGE20230869

FENG Tugen, LI Zhiping, ZHANG Jian, XIE Kang. Sludge solidification based on carbon dioxide foam cement slurry[J]. Chinese Journal of Geotechnical Engineering, 2024, 46(12): 2538-2547. DOI: 10.11779/CJGE20230869

Citation:

PDF (2029 KB)

Sludge solidification based on carbon dioxide foam cement slurry

1.
Key Laboratory of Ministry of Education for Geotechnical Engineering, Hohai University, Nanjing 210098, China
2.
CCCC National Engineering Research Center of Dredging Technology and Equipment Co., Ltd., Shanghai 200092, China

More Information

Received Date: September 07, 2023
Available Online: May 10, 2024

Graphical Abstract

Abstract

Abstract

River and lake dredging will produce a large amount of dredged sludge with high water content and compressibility. Using the carbon dioxide as the foam gas source to prepare carbon dioxide foam cement slurry and use it as the solidification material to carry out sludge improvement is of great significance to the reuse of dredged sludge resources and to achieve the goal of carbon neutrality. Based on the traditional air foam cement slurry preparation technology and ordinary cement-based carbon fixation mechanism, the carbon dioxide foam cement slurry is prepared with carbon dioxide instead of air, which is used to solidify the sludge. The mechanical properties of stone test blocks formed after the curing of foam slurry and the mechanical properties and microstructure of filler formed after the solidification of dredged sludge are studied experimentally. The results show that the best combination of foaming agent and foam stabilizer is A2 4g/L, C1 5g/L. The conversion rate of Ca (OH)₂ and CO₂ to CaCO₃ in the cement hydration hydrolysis product increases by about 26.1%. The optimal content of fly ash in cement slurry is 30%. The unconfined compressive strength, internal friction angle and cohesion of the solidified materials formed after curing approximately linearly increase with the content of foam slurry, while the permeability coefficient approximately linearly decreases with the content of foam slurry. The research results provide important guidance for the engineering application of sludge solidification and the way to "turn waste into treasure" of carbon dioxide.
- dredged silt,
- carbon dioxide,
- foam cement slurry,
- sludge solidification,
- mechanical property

FullText(HTML)

References (18)

References

[1]	王东星, 徐卫亚. 固化淤泥长期强度和变形特性试验研究[J]. 中南大学学报(自然科学版), 2013, 44(1): 332-339. WANG Dongxing, XU Weiya. Experimental study on long-term strength and deformation properties of solidified sediments[J]. Journal of Central South University (Science and Technology), 2013, 44(1): 332-339. (in Chinese)
[2]	丁建文, 张帅, 洪振舜, 等. 水泥-磷石膏双掺固化处理高含水率疏浚淤泥试验研究[J]. 岩土力学, 2010, 31(9): 2817-2822. doi: 10.3969/j.issn.1000-7598.2010.09.021 DING Jianwen, ZHANG Shuai, HONG Zhenshun, et al. Experimental study of solidification of dredged clays with high water content by adding cement and phosphogypsum synchronously[J]. Rock and Soil Mechanics, 2010, 31(9): 2817-2822. (in Chinese) doi: 10.3969/j.issn.1000-7598.2010.09.021
[3]	章荣军, 董超强, 郑俊杰, 等. 絮凝剂和缓凝剂对水泥固化疏浚淤泥浆效率的影响研究[J]. 岩土工程学报, 2019, 41(10): 1928-1935. doi: 10.11779/CJGE201910018 ZHANG Rongjun, DONG Chaoqiang, ZHENG Junjie, et al. Influences of flocculant and retarder on solidification efficiency of cement in treatment of dredged mud slurry[J]. Chinese Journal of Geotechnical Engineering, 2019, 41(10): 1928-1935. (in Chinese) doi: 10.11779/CJGE201910018
[4]	王协群, 刘宁, 李智奇, 等. 干湿循环作用下氯氧镁水泥基多相胶凝材料改性固化淤泥的水力-力学特性[J]. 岩土工程学报, 2023, 45(10): 2004-2013. doi: 10.11779/CJGE20220846 WANG Xiequn, LIU Ning, LI Zhiqi, et al. Hydro-mechanical properties of sludge stabilized with magnesium oxychloride cement-based multi-cementitious materials under influences of drying-wetting cycles[J]. Chinese Journal of Geotechnical Engineering, 2023, 45(10): 2004-2013. (in Chinese) doi: 10.11779/CJGE20220846
[5]	乔京生, 王旭影, 王冠泓, 等. 粒化高炉矿渣微粉固化淤泥质土的动力特性及微观机理[J]. 硅酸盐通报, 2021, 40(7): 2306-2312. QIAO Jingsheng, WANG Xuying, WANG Guanhong, et al. Dynamic characteristics and microscopic mechanism of muddy clay solidified by ground granulated blast-furnace slag[J]. Bulletin of the Chinese Ceramic Society, 2021, 40(7): 2306-2312. (in Chinese)
[6]	吴俊, 征西遥, 杨爱武, 等. 矿渣-粉煤灰基地质聚合物固化淤泥质黏土的抗压强度试验研究[J]. 岩土力学, 2021, 42(3): 647-655. WU Jun, ZHENG Xiyao, YANG Aiwu, et al. Experimental study on the compressive strength of muddy clay solidified by the one-part slag-fly ash based geopolymer[J]. Rock and Soil Mechanics, 2021, 42(3): 647-655. (in Chinese)
[7]	邓琪丰, 刘卫东, 韩云婷. 发泡剂对淤泥固化性能的影响研究[J]. 新型建筑材料, 2022, 49(7): 138-143. DENG Qifeng, LIU Weidong, HAN Yunting. Study on the effect of foaming agent on the solidification performance of silt[J]. New Building Materials, 2022, 49(7): 138-143. (in Chinese)
[8]	JONES M, MCCARTHY A. Utilising unprocessed low-lime coal fly ash in foamed concrete[J]. Fuel, 2005, 84(11): 1398-1409. doi: 10.1016/j.fuel.2004.09.030
[9]	JITCHAIYAPHUM K, SINSIRI T, CHINDAPRASIRT P. Cellular lightweight concrete containing pozzolan materials[J]. Procedia Engineering, 2011, 14: 1157-1164. doi: 10.1016/j.proeng.2011.07.145
[10]	KEARSLEY E P, WAINWRIGHT P J. Porosity and permeability of foamed concrete[J]. Cement and Concrete Research, 2001, 31(5): 805-812. doi: 10.1016/S0008-8846(01)00490-2
[11]	GOUAL M S, BALI A, DE BARQUIN F, et al. Isothermal moisture properties of clayey cellular concretes elaborated from clayey waste, cement and aluminium powder[J]. Cement and Concrete Research, 2006, 36(9): 1768-1776. doi: 10.1016/j.cemconres.2005.12.017
[12]	胡焕校, 罗玮, 唐良智, 等. 轻质泡沫水泥注浆材料的应用研究[J]. 中南林业科技大学学报, 2011, 31(2): 82-85. HU Huanxiao, LUO Wei, TANG Liangzhi, et al. The application research of lightweight foam cement in the grouting materials[J]. Journal of Central South University of Forestry & Technology, 2011, 31(2): 82-85. (in Chinese)
[13]	蔡光华, 刘松玉, 张正甫, 等. 二氧化碳泡沫法碳化加固软弱土的初探研究[J]. 地下空间与工程学报, 2015, 11(增刊1): 34-38. CAI Guanghua, LIU Songyu, ZHANG Zhengfu, et al. Preliminary study on carbonation of soft soil by carbon dioxide foam method[J]. Chinese Journal of Underground Space and Engineering, 2015, 11(S1): 34-38. (in Chinese)
[14]	NEVES A Jr, TOLEDO FILHO R D, DE MORAES REGO FAIRBAIRN E, et al. The effects of the early carbonation curing on the mechanical and porosity properties of high initial strength Portland cement pastes[J]. Construction and Building Materials, 2015, 77: 448-454. doi: 10.1016/j.conbuildmat.2014.12.072
[15]	ZHA X, WANG H, FENG G. The experimental research on the influence of silica fume on the property of cement-based materials[J]. Journal of Hebei Institute of Architecture and Civil Engineering, 2012: 514-518.
[16]	通用硅酸盐水泥: GB 175—2023[S]. 北京: 中国标准出版社, 2023. Common Portland Cement: GB 175—2023[S]. Beijing: Standards Press of China, 2023. (in Chinese)
[17]	用于水泥和混凝土中的粉煤灰: GB/T 1596—2017[S]. 北京: 中国标准出版社, 2023. Fly Ash Used for Cement and Concrete: GB/T 1596—2017[S]. Beijing: Standards Press of China, 2017. (in Chinese)
[18]	公路路基设计规范: JTG D30—2004[S]. 北京: 人民交通出版社, 2004. Specifications for Design of Highway Subgrades: JTG D30—2004[S]. Beijing: China Communications Press, 2004. (in Chinese)